Product ID:06 264F25B H-F HB TNK CTG GRAY
MSDS Date:02/26/1992
FSC:1440
NIIN:LWW004947
Kit Part:Y
MSDS Number: CHFXK

VALSPAR CORP

1101 THIRD ST SOUTH
MINNEAPOLIS, MN 55415
US

Emergency Phone: 800-228-5635

Info Phone: 612-332-7371

Cage: 13374

VALSPAR CORP

MINNEAPOLIS, MN 55415 US

Telephone: 612-332-7371

Cage: 91346

MINERAL SPIRITS; (ALIPHATIC PETROLEUM DISTILLATES)

CAS: 64742-88-7

Fraction By Weight: 1%

OSHA PEL N/K

ACGIH TLV: N/K

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 10-15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 20%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 5-10%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

EPOXY RESIN

CAS: 25036-25-3

Fraction By Weight: 20-30%

OSHA PEL N/K

ACGIH TLV: N/K

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 10%

OSHA PEL N/K

ACGIH TLV: N/K

BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA

CAS: 95-63-6

RTECS: DC3325000

Fraction By Weight: 5%

OSHA PEL 25 PPM

ACGIH TLV: 25 PPM

BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM, S, C

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-PROPANOL, 1-PROPOXY-; (PROPYLENE GLYCOL MONO PROPYL

CAS: 1569-01-3

RTECS: UB9351000

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: N/K

ETHANOL, 2-PROPOXY-; (ETHYLENE GLYCOL MONO PROPYL ETHER)

CAS: 2807-30-9

RTECS: KM2800000

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE IRRIT. CAN BE ABSORBED THRU
SKIN. HARMFUL IF INHALED. MAY AFFECT THE BRAIN, NERVOUS SYSTEM OR
RESP SYSTEM, CAUSING DIZZINESS, HEADACHE, NAUSEA OR RESP IRRIT.
OVEREXP TO INGREDS IN THIS PROD UCT MAY CAUSE NOSE & THROAT IRRIT,
EYE IRRIT, SKIN IRRIT. CHRONIC: POSSIBLE SENSITIZATION. NOTICE:
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: REPORTS HAVE ASSOC RPTD & PRLNG OCCUP
OVEREXP TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMUL/FA TAL. CONTAINS INGREDS WHICH MAY CAUSE
LIVER DAMAGE, KIDNEY DAMAGE, HEARING LOSS.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.

First Aid:EYES: FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15
MINUTES & GET MEDICAL ATTENTION. SKIN: WASH THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMD CLTHG & SHOES. WASH CLTHG BEFORE REUSE.
DESTROY CONTAMD SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. GET MEDICAL ATTENTION IMMEDIATELY. INGEST: GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:TCC
Flash Point:104F,40C
Lower Limits:1%
Upper Limits:17%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND/OR WATER
FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT
COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS OR AIRMASK
FOR LARGE SPILLS IN A CONFINED AREA. AVOID ALL PERSONAL CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAMES. KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT STORE ABOVE
120F.
Other Precautions:BASED ON PROD FL PT & VAP PRESS SUITABLE STORAGE
SHOULD BE PROVIDED I/A/W OSHA REG 1910.106. EMPTY CNTNRS MAY
CONTAIN PROD RESIDUE, INCL FLAMM/EXPLO VAPS. DO NOT CUT,
PUNCTURE/WELD ON OR NEAR CNTNR. A LL LABEL WARNINGS MUST BE
(SUPDAT)

Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW
RESPIRATOR MANUFACTURERS DIRECT IONS FOR RESPIRATOR USE.
Ventilation:REQUIRED FOR SPRAYING OR IN A CONFINED AREA. VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Protective Gloves:NEOPRENE OR OTHER NONPOROUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NEOPRENE OR PLASTIC APRON & PROTECTIVE
CLOTHING COVERING EXPOSED SKIN AREAS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: OBSERVED UNTIL CNTNR HAS BEEN CLEANED OR RECONDITIONED.

Boiling Pt:B.P. Text:243F,117C
Vapor Pres:6
Vapor Density:5.9
Spec Gravity:1.56
Evaporation Rate & Reference:0.5 (BUTYL ACETATE=1)
Solubility in Water:NO
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT.
Percent Volatiles by Volume:46.52

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON
DIOXIDE/MONOXIDE, METAL OXIDES, SULFUR OXIDES.

Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.